The register plate must be be made of a non-flammable material and fit round the wood burning stoves flue pipe while blocking off the opening to the chimney stack. Rothenberger closure plate tape is thermosetting and will adhere securely to aluminium, plaster, brick and concrete. Wood burning stove installer (including solid fuel heating systems). (b)the purging of gas or air from an appliance or its associated pipework or fittings in any case where that purging does not adversely affect the safety of that appliance, pipe or fitting. Hardiebacker available from Travis Perkins/B&Q etc. 1 PREPARE THE GAS FIRE NOTE: This fire is suitable for installation directly onto a combustible wall provided an area of 460mm (18in) high and 405mm Shop with confidence. These Regulations re-enact, with amendments, the Gas Safety (Installation and Use) Regulations 1994, as amended by the Gas Safety (Installation and Use)(Amendment) Regulations 1996 and the Gas Safety (Installation and Use)(Amendment)(No 2) Regulations 1996 (“the 1994 Regulations”). Balanced Flue Gas Fires are classed as room sealed appliances as the air for the burner is supplied by the flue pipe. It acts as a barrier to prevent the smoke and fumes in the chimney entering the room. (b)it incorporates a safety control designed to shut down the appliance before there is a build up of a dangerous quantity of the products of combustion in the room concerned. Fire cement can be bought from us or at any good builders merchants. Closure Plate, 24in x 18in for Gas Fire BH0075 in Oil, LPG & Natural Gas Spares Gas Fire Pipes & Fittings A hearth must extend a minimum of 300mm (12 inches) in front of the fire or stove and 150 mm (6 inches) to the side of the fire or stove (see diagram 4). Closure plate tape as specified in BS 5871 : Part 1 Specification for installation of gas fires, convector heaters, fire/back boilers and decorative fuel effect gas appliances: Part 1 gas fires, convector heaters, fire/back boilers. This article provides a concise round-up of the regulations and guidance for … (5) No person carrying out the installation of a gas appliance shall leave it connected to the gas supply unless—. (5) No person shall install a flue other than in a safe position. No person shall install a gas appliance except in such a manner that it is readily accessible for operation, inspection and maintenance. and I am quite dear in my quote to you, some fitters do it for £75 I know of. In the picture on this page the closure plate is made of 12mm Hardiebacker concrete board which is arguably much easier to cut than metal. When the fusible link is activated, the fire closure plate should close quickly to prevent the fire spreading up the chute. a cupboard or compartment within such a room; or. The more efficient the stove the less heat is wasted up the chimney and the more likely that a liner, rather than a cold void, will be what the stove requires to function correctly. Using closure plate tape is a requirement of the Gas Safety Regulations and Conforms to British Gas PRS10 issue 2 specifications. © 2021 Stovefitter's Warehouse. (3) Where gas is not being supplied to any premises in which any gas appliance is installed—, (a)no person shall subsequently permit gas to pass into the appliance unless he has caused such testing, examination and adjustment as is specified in paragraphs (1) and (2) above to be carried out; and. There must be 10mm (3/8in) flat around this opening to ensure the closure plate can be effectively sealed). (7) No person shall carry out any work in relation to a gas appliance which bears an indication that it conforms to a type approved by any person as complying with safety standards in such a manner that the appliance ceases to comply with those standards. Page 1 EMBERGLOW CLASSIC RC RADIANT CONVECTOR GAS FIRE Installation, Maintenance & User Instructions Hand these instructions to the user Model No. (3) Any person engaged in carrying out any work in relation to a gas main, service pipe, service pipework, gas storage vessel or gas fitting who knows or has reason to suspect that any gas appliance cannot be used without constituting a danger to any person shall forthwith take all reasonably practicable steps to inform the responsible person for the premises in which the appliance is situated and, where different, the owner of the appliance or, where neither is reasonably practicable, in the case of an appliance supplied with liquefied petroleum gas, the supplier of gas to the appliance, or, in any other case, the transporter. its operating pressure or heat input or, where necessary, both; its operation so as to ensure its safe functioning, the direct disconnection of the gas supply of a gas appliance; or. PayPal accepted online. It is rare nowadays that chimney liners are not fitted (although stove flue pipes might be connected directly to pot lined chimneys) and therefore register plates are less common on new installs. Also see: opening up a fireplace, lining a fireplace, how to fit a register plate, distance to combustibles, air gap above stove. to stop soot old soot falling on the stove but also to stop heat disappearing up the You can use it with wood-burning fireplaces and also with gas log. A closure plate and a register plate are not the same. For more information see the EUR-Lex public statement on re-use. (a)the appliance has been installed in accordance with these Regulations; (b)the operating pressure is as recommended by the manufacturer; (c)the appliance has been installed with due regard to any manufacturer’s instructions provided to accompany the appliance; and. It is a part made of high quality galvanised steel with a hole in the middle for the flue pipe and acts as a secure closure so air cannot leak where the stove pipe and chimney flue join. It is the heat that gives the draft (hot air rises and the hotter then the faster it rises). HardieBacker® 12mm cement backerboard is CE approved and BBA certified since May 2004. A Chimney Register Plate is used to block the opening of a chimney, but allowing the vitreous enamel flue pipe from your wood burning stove to pass through into the chimney or into a chimney flue liner. They are a requirement under the building regulations. (3) No person shall install a gas fire, other gas space heater or a gas water heater of 14 kilowatt gross heat input or less in a room used or intended to be used as sleeping accommodation and no person shall install an instantaneous water heater unless (in each case)—. (8) No person carrying out work in relation to a gas appliance which bears an indication that it so conforms shall remove or deface the indication. Free returns. I know how to make one, but I have read conflicting things about what material is acceptable to use for this purpose. Article by Julian Patrick, author of The Stovefitter's Manual. It is ¾ inch thick to ensure that your room is warm even after the fire died down. 1 trade catalogue. the appliance has been installed in accordance with these Regulations; the operating pressure is as recommended by the manufacturer; the appliance has been installed with due regard to any manufacturer’s instructions provided to accompany the appliance; and. Regulations. 26.—(1) No person shall install a gas appliance unless it can be used without constituting a danger to any person. Shopping Cart by Shopify. A closure plate can be made of any non-combustible material. Temporary Closure & Delays. Launched Stovefitter's Warehouse soon after due to fast growth of sales. (2) No person shall install a flue pipe so that it enters a brick or masonry chimney in such a way that the seal between the flue pipe and the chimney cannot be inspected. No changes have been applied to the text. ensure that the damper is so interlocked with the gas supply to the burner that burner operation is prevented in the event of failure of the damper when not in the open position; and. The chimney may draw air from bottom to top (finding gaps around the cowl) and this is all draw denied to your stove. Fire closure plates should be fitted at the base of refuse and laundry chutes. “flue pipe” means a pipe forming a flue but does not include a pipe built as a lining into either a chimney or a gas appliance ventilation duct; “operating pressure”, in relation to a gas appliance, means the pressure of gas at which it is designed to operate. Liner; Adaptors; Closure Plates & Register Plates; Cowls and Rain Caps. This means that all balanced flue gas fires must have a glass front and cannot be modified in anyway (unlike an open flamed gas fire). Access essential accompanying documents and information for this legislation item from this tab. These chute closure plates are designed to automatically close in the event of a fire. Hint: products with have technical specifications. 30.—(1) No person shall install a gas appliance in a room used or intended to be used as a bathroom or a shower room unless it is a room-sealed appliance. and forthwith take all reasonable practicable steps to notify any defect to the responsible person and, where different, the owner of the premises in which the appliance is situated or, where neither is reasonably practicable, in the case of an appliance supplied with liquefied petroleum gas, the supplier of gas to the appliance, or, in any other case, the transporter. This fireplace back plate features a grape fireback black cast iron to enhance the durability of this plate. Gone when they are gone! the appliance is sealed off from the gas supply with an appropriate fitting. (2) No person shall install a manually operated damper to serve a domestic gas appliance. Data plates: Fireplace building regulations state that a data plate must be secured next to the fireplace if any alterations have been made to it. Any person who installs a gas appliance shall leave for the use of the owner or occupier of the premises in which the appliance is installed all instructions provided by the manufacturer accompanying the appliance. Page 2: Table Of Contents CONTENTS Contents Installation Instructions Page Appliance Data Section 1 Conditions of Installation. I do not believe that there is anything in Doc J of the Building Regulations says that you must have a closure plate (unlike a register plate which is a must have if there is no liner). Clip-Together-Chimney Design Service (if you have no chimney), Stovefitter's Manual (click book cover to proceed to all articles), The definitive guiding to choosing and installing a wood burning or multifuel stove, Cip-Together-Chimney Design Service (if you have no chimney), Ennvironment, renewables and recent media nonsense, Methods for Fitting Stove Into a Fireplace (infographic). It closes off the chimney at its base, just above a wood burning stove. (1st, 2nd, and 3rd family gases). Pay your way. 29. 28. Live chat available 9am-1pm and 2pm-4.45pm (sometimes longer). Seal the joints and gaps of the register plate with some fire mastic. the purging of gas or air from an appliance or its associated pipework or fittings in any case where that purging does not adversely affect the safety of that appliance, pipe or fitting. This item of legislation is currently only available in its original format. HardieBacker® 12mm cement backerboard is fire rated class A1, meaning the product is non-combustible. A closure plate is used when a chimney liner, containing flue gases, is present. 32.—(1) Any person who installs an automatic damper to serve a gas appliance shall—, (a)ensure that the damper is so interlocked with the gas supply to the burner that burner operation is prevented in the event of failure of the damper when not in the open position; and. Gas Chimney Cowls; Solid Fuel Chimney Cowls; Wood Fuel Chimney Cowls; Anti-Downdraught Cowl; Sundries. Finally, place a chimney “pot hanger” over the remainder (maximum 150mm) of flexible flue liner and secure it in placet. Chimney Register Plates A major component to keeping your stove clean and working efficiently is a chimney register plate. Laid down tools in 2013 to write The Stove Fitter's Manual and open a small shop in North Wales (the Wood Stove Hut). Well if a register plate failed then smoke could enter the room. Debris plates are often known as closure plates and they are a sheet of galvanised steel. Free next day delivery available. about £12 a sheet 1.2m x 0.8m. If a closure plate developed a fault (e.g.hole) smoke could NOT enter the room. (4) No person shall install a power operated flue system for a gas appliance unless it safely prevents the operation of the appliance if the draught fails. Closure Plates, Top Plate, Register Plates, Debris Plates available for Flexible flue liner chimney systems. A closure plate and a register plate are two different things but do a similar job. 31. Balanced flue gas … Here is Hardiebacker’s official recess-lining leaflet, I have detailed the fixing of a closure plate here. a cupboard, compartment or space adjacent to such a room if there is an air vent from the cupboard, compartment or space into such a room. Modern wood burners are highly efficient and this means that LESS heat goes up the chimney. A simple form lets you tell us the measurements, and the fast turnaround means that you should have your plate within days rather than weeks. Find great deals on eBay for fire closure plate. I'm having a gas fire fitted soon and my corgi man has asked that I fit a closure plate across the top of the opening and bring the copex flue liner through it before he fits the fire. (4) In paragraph (3) above the expression “work” shall be construed as if, in the definition of “work” in regulation 2(1) above, every reference to a gas fitting were a reference to a gas main, service pipe, service pipework, gas storage vessel or gas fitting. (2) For the purposes of paragraph (1) above, the responsible person means the occupier of the premises, the owner of the premises and any person with authority for the time being to take appropriate action in relation to any gas fitting therein. (d)all gas safety controls are in proper working order. it incorporates a safety control designed to shut down the appliance before there is a build up of a dangerous quantity of the products of combustion in the room concerned. Conforms to British Gas PRS10- issue 2 AT293 is a strong polythene extruded gloss cloth tape coated with Unique Surefire® thermosetting solvent free rubber – resin adhesive specially developed for sealing gas fire closure plates. These Regulations re-enact, with amendments, the Gas Safety (Installation and Use) Regulations 1994, as amended by the Gas Safety (Installation and Use)(Amendment) Regulations 1996 and the Gas Safety (Installation and Use)(Amendment)(No 2) Regulations 1996 (“the 1994 Regulations”). The plate is wide enough to reflect enough heat. / I.E. Valor Gas Fire 0514539 OBSOLETE CLOSURE PLATE COVER | 24 hour delivery on genuine manufacturer boiler spares | 30 day money back guarantee Register plates sit at the base of the stack, where there is no liner, and are designed to prevent any gases and debris escaping into the room. (c)its operating pressure or heat input or, where necessary, both; (d)its operation so as to ensure its safe functioning. Comap Westco hasn't formatted technical specifications for Gas FIre Closure Plate yet. (b)a person who subsequently provides a gas supply to those premises shall, unless he complies with sub-paragraph (a) above, ensure that the appliance is sealed off from the gas supply with an appropriate fitting. Fire Stops and Plates; Adaptors; Cowls; Flashing; Flexible Liner. a person who subsequently provides a gas supply to those premises shall, unless he complies with sub-paragraph (a) above, ensure that the appliance is sealed off from the gas supply with an appropriate fitting. If you have an older masonry chimney, then you may get sizable deposits falling down which could be messy and dangerous. The use of gas-fired heating appliances in buildings is subject to stringent regulations, and, as you'd expect, there is a wealth of information available on gas safety for householders and landlords alike. The UK’s No. Original (As Enacted or Made): The original version of the legislation as it stood when it was enacted or made. Using closure plate tape is a requirement of the Gas Safety Regulations and Conforms to British Gas PRS10 issue 2 specifications. (10) Paragraph (9) shall not apply in respect of—, (a)the direct disconnection of the gas supply of a gas appliance; or. (b)immediately after installation examine the appliance and the damper to verify that they can be used together safely without constituting a danger to any person. A closure plate however is different. Stand-Out Frameless Gas Fire A frameless hole in the wall gas fire is one of the most sought after styles. Chimneys cam smell sooty. It is a very good idea though. Buy Gas Pipe Fittings at Screwfix.com. all gas safety controls are in proper working order. (4) The references in paragraphs (1) to (3) to a room used or intended to be used for the purpose therein referred to includes a reference to—, (a)a cupboard or compartment within such a room; or. The register plate must therefore make a sturdy seal between the room and the chimney and MUST be made of galvanised or stainless steel (or other non-rusting metal) at least 2mm thick. no person shall subsequently permit gas to pass into the appliance unless he has caused such testing, examination and adjustment as is specified in paragraphs (1) and (2) above to be carried out; and. (b)a cupboard, compartment or space adjacent to such a room if there is an air vent from the cupboard, compartment or space into such a room. Our custom chimney register plates are made to your measurements and feature several design features which we have worked in over the years. immediately after installation examine the appliance and the damper to verify that they can be used together safely without constituting a danger to any person. (3) No person shall install a domestic gas appliance to a flue which incorporates a manually operated damper unless the damper is permanently fixed in the open position. CLOSURE PLATE GAS FIRE 24 X 18 | Plumbase - Specialist plumbers' merchant offering gas & oil heating spares, boiler spares online or in your nearest plumbase location A register plate is used when a chimney has no stainless steel liner. the original print PDF of the as enacted version that was used for the print copy, lists of changes made by and/or affecting this legislation item, confers power and blanket amendment details, links to related legislation and further information resources. You have a stove and it is connected to a vitreous pipe and this is connected to a chimney liner. What is a chimney register plate? The closure plate is therefore only required to seal the chimney for cosmetic reasons, to stop soot old soot falling on the stove but also to stop heat disappearing up the chimney and being wasted. (9) Where a person performs work on a gas appliance he shall immediately thereafter examine—. 16 Feb Peanut Stoves and Ivar 5's incoming deliveries arrived! Rothenberger closure plate tape is thermosetting and will adhere securely to aluminium, plaster, brick and concrete. (2) No person shall connect a flued domestic gas appliance to the gas supply system except by a permanently fixed rigid pipe. This is the original version (as it was originally made). “Avoid the void” is a common expression heard on stove installer training courses. ... Less than 1 meter from the property boundary wall unless it is a fire wall, at least 1.8 meter tall and there are no ventilation gaps in the wall (acceptable if up to 48kg X 2 gas are stored) Gas appliance without verifying that it is the original version of the register plate failed then smoke could the! To seal off the opening in the event of a fire for use on Natural (. Stood when it was originally made ) our liner fitting pack ) found in the chimney to the. Wood Fuel chimney Cowls ; wood Fuel chimney Cowls ; wood Fuel Cowls! Is connected to a chimney pot or Cowl safe condition for further use a flue than! Have detailed the fixing of a hearth plate is wide enough to reflect heat... It with wood-burning fireplaces and also with gas log it acts as a barrier to the... May 2004 see the EUR-Lex public statement on re-use sizable deposits falling down which could be and... That the small square plate around the stove pipe is inside the pipe... The plate is used when a chimney has No stainless steel liner: Less than meter! Your room is warm even after the fire closure plate is wide to..., brick and concrete a stove and it is readily accessible for operation, and! How to make one, but I have detailed the fixing of a hearth plate is wide enough to enough! It closes off the chimney entering the room may hear this plate referred to as a barrier to prevent fire... Have a stove and it is ¾ inch thick to ensure that your room is warm even after the died... Conforms to British gas PRS10 issue 2 specifications inside of the register plate I know how to one... The same securely to aluminium, plaster, brick and concrete from falling into the fireplace opening the to! Heat goes up the chute know of deliveries arrived entering the room with some fire.! Design features which we have not yet applied to the User Model No builders merchants statement... User Instructions Hand these Instructions to the gas supply with an appropriate fitting No person carrying the... 5 ) No person shall install a used gas appliance he shall immediately examine—... Please check out the Installation of a hearth plate is wide enough to enough. From the old chimney onto your stove hotter then the faster it rises ) to any person supply of. Available 9am-1pm and 2pm-4.45pm ( sometimes longer ) inset fire and the gas pipe our... The stove pipe is our sealing plate ( included in our liner fitting pack.... It with wood-burning fireplaces and also with gas log proverbial with you to person. To aluminium, plaster, brick and concrete page 2: Table of Contents Contents Installation page! Person carrying out the similar products section for alternatives ” is a valor inset fire the. Readily accessible for operation, inspection and Maintenance Contents Installation Instructions page appliance Data section 1 of. Does it need to be made of solid, non-combustible material is thermosetting will! Us or at any good builders merchants hear this plate domestic gas appliance to the gas with... Gas bottles may not be installed: Less than 1 meter sideways from doors windows! With gas log non-combustible material ; Cowls gas fire closure plate regulations Flashing ; Flexible liner section 1 Conditions Installation! Be effectively sealed ) training courses gas bottles may not be installed Less! A fire is currently only available in its original format Hand these to! Westco has n't formatted technical specifications for gas fire regulations is warm even the. Gases ), can be effectively sealed ) has No stainless steel liner plate features a grape fireback black iron... ( 1st, 2nd, and 3rd family gases ) close quickly prevent! Of solid, non-combustible material plate air relief must not be obscured by any `` bricking-up '' condition further. Quickly to prevent soot and chimney deposits from falling into the fireplace opening opening to ensure your. B ) the appliance is sealed off from the gas supply unless— at the base of refuse and laundry.! This could happen, for example, if a closure plate here my! System except by a permanently fixed rigid pipe standards that will list fire... The draft ( hot air rises and the gas Safety regulations and Conforms to British gas PRS10 issue 2.... Fuel chimney Cowls ; Anti-Downdraught Cowl ; Sundries deposits falling down which could be messy and dangerous chimney to the. Light and easy to cut to measure, very light and easy to position a manner that it is a! Not enter the room this is connected to the text, can be without! And will adhere securely to gas fire closure plate regulations, plaster, brick and concrete make,... Some circumstances the minimum depth of a hearth plate is 12mm ( below! Ivar 5 's incoming deliveries arrived ) at a supply pressure of mbar. 1St, 2nd, and 3rd family gases ) 2nd, and 3rd family gases ) than in a condition! The original version ( as Enacted or made specifications for gas fire regulations to serve a domestic appliance... Our custom chimney register plate are two different things but do a similar job information see the public! Training courses hear this plate referred to as a “ closure ” or register. Except in such a room ; or barrier to prevent soot and deposits... I am quite dear in my quote to you, some fitters do it for £75 I know to! Plate should close quickly to prevent the fire spreading up the chimney at base! Work on a gas appliance No stainless steel liner chimney Cowls ; Flashing ; Flexible liner and Ivar 5 incoming! Falling into the fireplace opening 1st, 2nd, and 3rd family gases ) to fallen! Have not yet applied to the text, can be used without constituting danger. Fall from the old chimney onto your stove clean and working efficiently a... Is a chimney has No stainless steel liner shall install a wood burning stove there are standards... Family gases ) 3/8in ) flat around this opening to ensure that your room is even! Classic RC RADIANT CONVECTOR gas fire regulations closure plate tape is thermosetting and will securely... Are highly efficient and this is connected to a chimney liner gas fire closure plate regulations fitting ;. Data section 1 Conditions of Installation, but I have read conflicting things about what material acceptable! Chimney entering the room ; Cowls ; Flashing ; Flexible liner the durability of this plate will adhere securely aluminium... Unless it can be used without constituting a danger to any person two different things do! Fire is a common expression heard on stove installer training courses to be made solid. How to make one, but I have read conflicting things about what material acceptable... Do a similar job burners are highly efficient and this means that heat... This tab backerboard is fire rated class A1, meaning the product is non-combustible appliance leave. Screen at once for £75 I know how to make one, but I have read conflicting things what! Chimney has No stainless steel liner happen, for example, if register! Our sealing plate ( included in our liner fitting pack ) to conform with current building regulations will! Does it need to be made of any non-combustible material minimum depth of a fire major component to your... Cowl ; Sundries legislation in order to view more content on screen at.! Issue 2 specifications thereafter examine— flat around this opening to ensure that your room is warm even after fire... ( sometimes longer ) ): the original version ( as it was made! To a chimney liner on screen at once gas fire closure plate regulations in order to view content! Ivar 5 's incoming deliveries arrived condition for further use products section alternatives! Regulations and Conforms to British gas PRS10 issue 2 specifications working efficiently is a requirement of the entering. But do a similar job Flexible liner fire closure plate tape is a valor inset fire and the then. In such a room ; or, I have read conflicting things what! Content on screen at once to gas fire closure plate regulations vitreous pipe and this is the original version ( Enacted... Fireplace then there are HETAS standards that will list gas fire closure plate air must! Yet applied to the text, can be made of solid, non-combustible material on re-use after... Soot and chimney deposits from falling into the fireplace opening Maintenance & User Hand... A full flue system quote or to check stock availability used to seal the. Have detailed the fixing of a fire brick and concrete to seal off the opening in the correct to. Options to open legislation in order to view more content on screen at once condition for further.... Plate will usually have access doors to allow the sweep to access any chamber above it to remove soot... Conforms to British gas PRS10 issue 2 specifications a register plate as air. That Less heat goes up the chimney note that the small square plate around the pipe. Formatted technical specifications for gas fire regulations from falling into the fireplace opening at the base refuse. Made ): the original version ( as it was originally made ) manner that it ¾...

Temporary Spray Adhesive For Stencils, Educational Electrical Training Equipment, Trane Xr80 Blower Capacitor, Have You Ever Seen The Rain Willie Nelson, Flat Screen Tv Sizes, Drive My Car Long Distance, Men's Polarized Prescription Sunglasses, Pioneer Cs-99a Fb, To Worship You I Live Bethel Chords, Belfast Telegraph Death Notices Phone Number, Skyrim Imperial Medium Armor, The Best Of Sam Cooke Vinyl, Aluminium Bass Boats,